VIAIR 20003 User Manual download pdf (Page 6)

120 PSI FAST-FILL AIR SOURCE KIT

USER MANUAL

AIR TANK PRECAUTIONS:

IMPORTANT:

a.Theairsourcekitairtankisratedfor150PSImaximum

 workingpressure.Donotoverll.Overllingmayresultin

 deathorseriousinjury.

b.Tankisnottobeusedasabreathingdevice.

c.AlwayswearANSIapprovedsafetyglasseswhen

operating air tank.

d.Bleedpressurefromtankaftereachuse,andbefore

 servicingoraddingattachments.

e.Useonlyattachmentsortoolsratedfor150PSIworking

pressure or less.

DRAIN TANK OFTEN TO REMOVE CONDENSATE.

FAILURE TO DRAIN TANK WILL ALLOW TANK TO

RUST INTERNALLY.

a.Toremoveanyaccumulatedcondensationinsidethetank,

 bleedpressurefromtankuntilpressureisapproximately

 5PSIto20PSI.

b.Drainwaterfromtankbyopeningthedraincockdrainvalve.

c.Ifdraincockisplugged,releaseallairpressurefromtank,

 removedrainvalveandclean,thenreinstall.

d.Aftercondensatehasbeendrained,closethedraincock.

IMPORTANT:ObserveairtankDateofManufacture(stamped

ontankleg).Replaceairtank2to5yearsfromdateairtank

wasrstused,orusethedateofmanufactureasreference.

Youradherencetoairtankdrainingguidelineswilldetermine

thereplacementdateofyourairtank.RUSTEDTANKSCAN

FAILCAUSINGEXPLOSIONSORFATALINJURIES.Discard

tank immediately if tank is rusted.

NOTE: Whenusingasafetypressurereliefvalve,pointthe

safetypressurereliefvalveawayfromyourbody.Usethepull

ringonthesafetyreliefvalve;openthereliefvalvetoventany

pressureinsidethetankbeforeattemptingtoservicetank.

1 2 3 4 5 6 7 8 9 10

No comments

VIAIR 20003 User Manual Page 6